NH纽皇高性能防腐漆
地址：上海市闵行区中春路6966号 电话：86-021-52277860 54880584 科技创造纽皇
THERMO 300 FINISH 有机硅耐热面漆 300 Protective Coatings
PRODUCT DESCRIPTION A heat resisting paint based on modified silicone resin and aluminium powder.
产品简介 由改性有机硅树脂与铝粉组成的耐热涂料。
RECOMMENDED USE For long-term protection of hot pipelines, exhaust pipes, smoke stacks and other
用途 hot surfaces at temperatures up to 300℃ and 350℃ at a short time.
长效保护温度高达 300℃（瞬时温度350℃）的热管道、排气管、烟囱和其它
热表面。
FEATURES Excellent heat resistance (Up to 300℃)
产品特性 极好的耐热性（到300℃）
Good weathering resistance
极好的耐候性
Good applicability
极好的施工性能
PHYSICAL PROPERTIES
基本数据
Color Silver
颜色 银色
Finish Gloss
光泽 有光
Volume Solids 25%
体积固体份
Flash Point Greater than 27℃
闪点 27℃以上
Film thickness Dry : 20-30 microns/coat Wet:80-120microns/coat
涂装膜厚 干膜: 20-30 微米/道 湿膜:80-120 微米/道
Theoretical Coverage 0.082kg/m
2
/20microns
理论涂布率 0.082 千克/平方米/20 微米
Practical coverage depending on surface conditions, environment, applications, etc.
实际涂布率与表面处理, 外界环境, 施工方法等多种因素有关。
APPLICATION
施工
Application Temperature -5℃-40℃
施工温度
Mixing Mix thoroughly with power agitator
混合 使用动力工具搅拌均匀
Mixing Ratio One component coating
混合比例 单组份涂料
Application Methods Airless spray, air spray, brush and roller
施工方法 无气喷涂、空气喷涂、刷涂、滚涂
NH纽皇高性能防腐漆
地址：上海市闵行区中春路6966号 电话：86-021-52277860 54880584 科技创造纽皇
Protective Coatings
Airless spray 无气喷涂
Nozzle tip 喷嘴尺寸 0.33mm-0.43mm
Nozzle pressure 出口压力 ≥10Mpa
Thinning ratio 稀释比率 0- 5% by weight（重量比）
Brush/Roller 刷涂、滚涂
Thinning ratio 稀释比率 0- 5% by weight（重量比）
Thinner Paint Thinner X
稀释剂 稀释剂 X
Drying time & Temperature 温度 5℃ 20℃ 30℃
Overcoating interval Surface dry 指触干燥 3hrs 1hr 1hr
干燥时间&涂装间隔 Touchdry 半硬干燥 5hrs 3hrs 3hrs
Min. interval 最小涂装间隔 16hrs 12hrs 8hrs
Max. interval 最大涂装间隔
Full cure: must bake in 200℃-250℃ for 1hr
完全固化：必须在 200℃~250℃烘烤 1 小时
Typical undercoat THERMO 300 PRIMER, SD ZINC PRIMER 2000
适用下涂 有机硅耐热底漆300，无机富锌底漆 2000
Typical topcoat
适用上涂
STORAGE Store in dry,cool condition and away from sources of heat and ignition. Containers
贮存 must be kept tightly closed.
贮存于干燥阴凉的环境中，远离热源及火源。包装桶必须保持封闭。
Shelf life 12months from date of production (25℃)
贮存期限 自生产之日起12 个月（25℃）
DISCLAIMER The information given on this sheet is to the best of our knowledge and accurate at
提请注意 the time of issuing. Since conditions of use are beyond the manufacturer ’s control,
information contained herein is without warranty, implied or otherwise, and the
suitability of the material for the use contemplated is the sole responsibility of the
buyer. The information contained on this data sheet is subject to modification at
any time due to our policy of modification and product development.Please check
this date sheet is current prior to using the product.
本说明书所提供信息均为目前我方所掌握全面正确的资料,鉴于产品使用条
件非我方所能控制，此中信息不含担保，即仅在选取产品上对买方负责。由
于我公司产品及生产工艺的不断发展，本说明书的内容也会随时进行更改，
此中所有信息均以我方确认为主。产品使用前，请确认所持说明书为新版
本。
www.shnhyq.com
Issued Date 2011/6/27
发行日期 2011/6/27